Page 1 of 2 12 LastLast
Threads 1 to 20 of 36

Forum: Tech Library

Post instructions, diagrams, how-to's or anything else you feel would help a fellow Willys or Jeep owner! This is the tech library, so if you'd like to post a tech question, please do so in the "Tech Questions, Answers etc." Forum. Thank you for sharing your knowledge!

  1. Sticky Thread Sticky: Warn Overdrive Manual

    Started by bmorgil, 09-03-2023 06:53 AM
    • Replies: 0
    • Views: 1,914
    09-03-2023, 06:53 AM Go to last post
  2. Sticky Thread Sticky: Start-up Best Practices

    Started by LarrBeard, 06-11-2018 10:45 AM
    2 Pages
    1 2
    • Replies: 18
    • Views: 34,063
    08-01-2023, 10:17 AM Go to last post
  3. Sticky Thread Sticky: The Introduction of the Dana 27

    Started by oblvnnwtnjhn, 02-15-2023 10:59 PM
    • Replies: 5
    • Views: 3,996
    02-25-2023, 09:21 AM Go to last post
  4. Sticky Thread Sticky: Square O-rings for Older Warn Locking Hubs

    Started by test1328, 02-02-2023 02:29 PM
    • Replies: 6
    • Views: 3,487
    02-04-2023, 03:17 AM Go to last post
  5. Sticky Thread Sticky: P.T.O Information

    Started by gmwillys, 02-01-2023 02:01 AM
    • Replies: 0
    • Views: 2,014
    02-01-2023, 02:01 AM Go to last post
  6. Sticky Thread Sticky: Correct Axle Carrier Bearing Cap Torque

    Started by bmorgil, 11-02-2022 03:09 PM
    • Replies: 0
    • Views: 17,540
    11-02-2022, 03:09 PM Go to last post
  7. Sticky Thread Sticky: A New Piston Choice for the L134 & F134

    Started by bmorgil, 10-29-2022 07:59 AM
    • Replies: 1
    • Views: 2,930
    10-31-2022, 12:17 AM Go to last post
  8. Sticky Thread Sticky: Obtaining / Setting a Ring and Pinion Gear Pattern

    Started by Wulfie, 07-11-2022 08:03 PM
    3 Pages
    1 2 3
    • Replies: 25
    • Views: 14,905
    07-27-2022, 06:13 AM Go to last post
    • Replies: 5
    • Views: 6,489
    04-20-2022, 04:32 PM Go to last post
  9. Sticky Thread Sticky: Unleadead fuel in your Classic

    Started by bmorgil, 08-03-2021 04:42 PM
    • Replies: 1
    • Views: 4,953
    08-04-2021, 12:57 AM Go to last post
  10. Sticky Thread Sticky: T90 Teardown Important Correction to Rick Stivers Guide

    Started by bmorgil, 08-01-2021 11:25 AM
    • Replies: 1
    • Views: 4,926
    08-01-2021, 12:13 PM Go to last post
  11. Sticky Thread Sticky: CJ-2 through CJ-6 fuel pumps and pressures

    Started by bmorgil, 05-26-2021 06:14 AM
    • Replies: 0
    • Views: 4,621
    05-26-2021, 06:14 AM Go to last post
  12. Sticky Thread Sticky: Speedi Sleeve for MB Axle

    Started by LTjackMB41, 04-12-2021 11:35 AM
    • Replies: 2
    • Views: 11,139
    04-12-2021, 02:03 PM Go to last post
  13. Sticky Thread Sticky: Make it go "HOOT" tracing an itermittent horn

    Started by LarrBeard, 03-27-2021 07:15 PM
    • Replies: 0
    • Views: 8,537
    03-27-2021, 07:15 PM Go to last post
  14. Sticky Thread Sticky: Closed Knuckle and Steering Box Lubrication

    Started by bmorgil, 03-27-2020 07:51 AM
    • Replies: 4
    • Views: 41,860
    01-18-2021, 04:30 PM Go to last post
  15. Sticky Thread Sticky: Carter YF carburetor info

    Started by Patriot, 11-02-2020 05:39 PM
    carteryf
    • Replies: 5
    • Views: 41,766
    12-23-2020, 12:43 AM Go to last post
  16. Sticky Thread Sticky: CJ rear drivesahft bind after lifting or new springs

    Started by bmorgil, 08-07-2019 07:16 PM
    • Replies: 3
    • Views: 27,367
    09-28-2020, 10:25 AM Go to last post
  17. Sticky Thread Sticky: Auto-lite Service Parts Catalog

    Started by AmyB, 09-08-2020 08:29 AM
    auto-lite
    • Replies: 0
    • Views: 28,990
    09-08-2020, 08:29 AM Go to last post
  18. Sticky Thread Sticky: Converting an Oil bath Air Cleaner to An Element

    Started by bmorgil, 09-01-2020 05:13 PM
    • Replies: 3
    • Views: 13,091
    09-02-2020, 08:48 AM Go to last post
    • Replies: 0
    • Views: 12,382
    08-18-2020, 08:38 AM Go to last post
  19. Sticky Thread Sticky: T90 Transmission and Dana 18 Transfer case Lube Levels

    Started by bmorgil, 06-03-2020 07:03 AM
    • Replies: 1
    • Views: 20,291
    07-20-2020, 11:51 PM Go to last post
  20. Sticky Thread Sticky: The correct lube for a Jeep synchronized transmission

    Started by bmorgil, 01-11-2020 07:21 AM
    • Replies: 3
    • Views: 27,397
    04-27-2020, 07:23 PM Go to last post
  21. Sticky Thread Sticky: JEEP Serial Numbers, Production Figures, & Models

    Started by bmorgil, 04-10-2020 01:22 PM
    • Replies: 0
    • Views: 14,104
    04-10-2020, 01:22 PM Go to last post
  22. Sticky Thread Sticky: The M38A1 24 volt ignition system and coil

    Started by bmorgil, 03-29-2020 08:07 PM
    • Replies: 0
    • Views: 15,333
    03-29-2020, 08:07 PM Go to last post
  23. Sticky Thread Sticky: The Right Motor Oil

    Started by bmorgil, 03-03-2020 08:53 AM
    • Replies: 7
    • Views: 22,340
    03-06-2020, 06:37 PM Go to last post
  24. Sticky Thread Sticky: The Correct Grease for the "Zerks"

    Started by bmorgil, 02-03-2020 06:53 PM
    • Replies: 0
    • Views: 11,382
    02-03-2020, 06:53 PM Go to last post
    • Replies: 0
    • Views: 8,000
    02-03-2020, 11:50 AM Go to last post
  25. Sticky Thread Sticky: CJ-3A Owners Manual PDFs

    Started by AmyB, 12-30-2019 11:20 AM
    willys cj3a owners manual
    • Replies: 1
    • Views: 26,111
    01-01-2020, 02:54 PM Go to last post
  26. Sticky Thread Sticky: TM9-1804A - Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38

    Started by AmyB, 12-30-2019 11:41 AM
    willys m38 clutch engine
    • Replies: 0
    • Views: 12,329
    12-30-2019, 11:41 AM Go to last post
    • Replies: 0
    • Views: 26,693
    12-02-2019, 10:19 AM Go to last post
  27. Sticky Thread Sticky: Spicer Service Manual - Failure Analysis AXSM-0020 Dec 2015

    Started by AmyB, 12-02-2019 10:15 AM
    axles, bearings, gears, service manual, spicer
    • Replies: 0
    • Views: 28,289
    12-02-2019, 10:15 AM Go to last post
  28. Sticky Thread Sticky: How fast is the RPM at speed, or the speed at RPM?

    Started by bmorgil, 10-20-2019 09:15 AM
    • Replies: 0
    • Views: 26,734
    10-20-2019, 09:15 AM Go to last post
    • Replies: 2
    • Views: 18,546
    10-15-2019, 08:57 AM Go to last post
    • Replies: 0
    • Views: 17,041
    10-15-2019, 08:56 AM Go to last post
    • Replies: 0
    • Views: 21,002
    10-14-2019, 09:47 AM Go to last post
  29. Sticky Thread Sticky: Oil Bath Air Cleaners 101

    Started by LarrBeard, 08-25-2018 10:07 AM
    • Replies: 5
    • Views: 41,890
    05-15-2019, 03:06 PM Go to last post
  30. Sticky Thread Sticky: How Do I Set Up An 8-volt Regulator?

    Started by LarrBeard, 04-14-2019 01:27 PM
    • Replies: 0
    • Views: 31,971
    04-14-2019, 01:27 PM Go to last post
  31. Sticky Thread Sticky: Original Warn Hub Lock Instructions

    Started by bmorgil, 02-06-2019 12:50 PM
    • Replies: 0
    • Views: 20,960
    02-06-2019, 12:50 PM Go to last post
  32. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section II

    Started by LarrBeard, 08-26-2018 02:49 PM
    • Replies: 0
    • Views: 32,563
    08-26-2018, 02:49 PM Go to last post
  33. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section I

    Started by LarrBeard, 08-26-2018 02:19 PM
    • Replies: 0
    • Views: 26,469
    08-26-2018, 02:19 PM Go to last post
  34. Sticky Thread Sticky: Old Jeep Generators; An Introduction

    Started by LarrBeard, 08-24-2018 09:22 AM
    • Replies: 0
    • Views: 17,231
    08-24-2018, 09:22 AM Go to last post
  1. Cool willys books, pamphlets etc.

    Started by 56willys, 10-03-2023 07:31 PM
    • Replies: 6
    • Views: 9,526
    10-06-2023, 08:27 AM Go to last post
  2. going backwards..

    Started by churchkey, 12-01-2021 08:55 PM
    • Replies: 2
    • Views: 3,900
    12-07-2021, 09:06 PM Go to last post
  3. Wiring Diagram for CJ2A 12V system

    Started by Willys1948, 09-28-2021 11:54 AM
    • Replies: 0
    • Views: 4,020
    09-28-2021, 11:54 AM Go to last post
  4. Oil Pressure

    Started by The_Green_Bean_59, 03-06-2021 02:50 AM
    oil, pressure
    • Replies: 6
    • Views: 15,326
    03-06-2021, 01:36 PM Go to last post
    • Replies: 16
    • Views: 49,349
    10-05-2020, 06:53 PM Go to last post
  5. Diagram of all zerks that need grease on an M38A1?

    Started by One65r, 07-23-2020 04:30 PM
    • Replies: 4
    • Views: 14,811
    08-03-2020, 02:50 AM Go to last post
    • Replies: 2
    • Views: 14,701
    04-06-2020, 05:28 PM Go to last post
  6. Original Carburator?

    Started by Jake-1, 04-05-2020 03:47 PM
    carburator
    • Replies: 0
    • Views: 11,210
    04-05-2020, 03:47 PM Go to last post
  7. Solex Carburetor Tips and Info:

    Started by AmyB, 08-15-2013 01:42 PM
    carburetor, solex, tech tips, willys jeep
    • Replies: 4
    • Views: 27,388
    03-12-2020, 06:57 AM Go to last post
  8. Tranny and Transfer case manuals

    Started by mhead, 02-11-2020 05:41 AM
    • Replies: 1
    • Views: 13,207
    02-11-2020, 08:28 AM Go to last post
  9. Manual CJ5

    Started by mhead, 12-31-2019 10:37 AM
    • Replies: 1
    • Views: 14,515
    12-31-2019, 03:06 PM Go to last post
    • Replies: 0
    • Views: 26,654
    09-07-2019, 05:46 PM Go to last post
    • Replies: 2
    • Views: 22,151
    08-19-2019, 07:50 AM Go to last post
  10. Champion Radiator in a CJ3A

    Started by bmorgil, 06-30-2019 09:11 AM
    3 Pages
    1 2 3
    • Replies: 21
    • Views: 97,879
    07-08-2019, 07:47 PM Go to last post
  11. 12 volt conversion questions

    Started by Jbudd43MB, 04-29-2019 10:04 PM
    12 volt, 1943, 6 volt, timing, willysmb
    • Replies: 0
    • Views: 26,263
    04-29-2019, 10:04 PM Go to last post
  12. Problemas de encendido

    Started by carl gerard, 02-01-2019 10:43 AM
    • Replies: 1
    • Views: 44,451
    02-16-2019, 11:13 PM Go to last post
    • Replies: 3
    • Views: 24,804
    02-10-2019, 06:02 PM Go to last post
  13. Three relay Voltage/Current Regulator Video

    Started by LarrBeard, 08-02-2018 07:28 PM
    • Replies: 0
    • Views: 22,845
    08-02-2018, 07:28 PM Go to last post
  14. Ammeter vs. Volt gauge

    Started by danielbaldwin, 07-11-2018 11:18 AM
    ammeter, electrical gauge, volt meter
    • Replies: 2
    • Views: 32,119
    07-12-2018, 10:21 AM Go to last post
  15. Cooling issues

    Started by Undone, 06-15-2018 08:59 PM
    • Replies: 3
    • Views: 26,655
    06-21-2018, 10:29 PM Go to last post

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •