Page 1 of 2 12 LastLast
Threads 1 to 20 of 36

Forum: Tech Library

Post instructions, diagrams, how-to's or anything else you feel would help a fellow Willys or Jeep owner! This is the tech library, so if you'd like to post a tech question, please do so in the "Tech Questions, Answers etc." Forum. Thank you for sharing your knowledge!

  1. Sticky Thread Sticky: The Introduction of the Dana 27

    Started by oblvnnwtnjhn, 02-15-2023 10:59 PM
    3 Attachment(s)
    • Replies: 5
    • Views: 1,542
    bmorgil
    02-25-2023, 09:21 AM Go to last post

  2. Sticky Thread Sticky: Square O-rings for Older Warn Locking Hubs

    Started by test1328, 02-02-2023 02:29 PM
    4 Attachment(s)
    • Replies: 6
    • Views: 1,217
    gmwillys
    02-04-2023, 03:17 AM Go to last post

  3. Sticky Thread Sticky: P.T.O Information

    Started by gmwillys, 02-01-2023 02:01 AM
    • Replies: 0
    • Views: 438
    gmwillys
    02-01-2023, 02:01 AM Go to last post

  4. Sticky Thread Sticky: Correct Axle Carrier Bearing Cap Torque

    Started by bmorgil, 11-02-2022 03:09 PM
    • Replies: 0
    • Views: 1,630
    bmorgil
    11-02-2022, 03:09 PM Go to last post

  5. Sticky Thread Sticky: A New Piston Choice for the L134 & F134

    Started by bmorgil, 10-29-2022 07:59 AM
    • Replies: 1
    • Views: 1,277
    gmwillys
    10-31-2022, 12:17 AM Go to last post

  6. Sticky Thread Sticky: Ring and Pinion Gear Pattern

    Started by Wulfie, 07-20-2022 07:11 PM
    2 Pages •
    1 2
    10 Attachment(s)
    • Replies: 18
    • Views: 292
    bmorgil
    07-27-2022, 06:13 AM Go to last post

  7. Sticky Thread Sticky: Differences between L 134 front engine plate and F 134 front engine plate

    Started by Wulfie, 04-19-2022 09:49 PM
    3 Attachment(s)
    • Replies: 5
    • Views: 4,271
    LarrBeard
    04-20-2022, 04:32 PM Go to last post

  8. Sticky Thread Sticky: Start-up Best Practices

    Started by LarrBeard, 06-11-2018 10:45 AM
    2 Pages •
    1 2
    1 Attachment(s)
    • Replies: 16
    • Views: 26,134
    Wulfie
    04-20-2022, 08:11 AM Go to last post

  9. Sticky Thread Sticky: Unleadead fuel in your Classic

    Started by bmorgil, 08-03-2021 04:42 PM
    • Replies: 1
    • Views: 3,437
    5JeepsAz
    08-04-2021, 12:57 AM Go to last post

  10. Sticky Thread Sticky: T90 Teardown Important Correction to Rick Stivers Guide

    Started by bmorgil, 08-01-2021 11:25 AM
    1 Attachment(s)
    • Replies: 1
    • Views: 3,524
    5JeepsAz
    08-01-2021, 12:13 PM Go to last post

  11. Sticky Thread Sticky: CJ-2 through CJ-6 fuel pumps and pressures

    Started by bmorgil, 05-26-2021 06:14 AM
    • Replies: 0
    • Views: 3,317
    bmorgil
    05-26-2021, 06:14 AM Go to last post

  12. Sticky Thread Sticky: Speedi Sleeve for MB Axle

    Started by LTjackMB41, 04-12-2021 11:35 AM
    mb axle seal. 1 Attachment(s)
    • Replies: 2
    • Views: 8,304
    gmwillys
    04-12-2021, 02:03 PM Go to last post

  13. Sticky Thread Sticky: Make it go "HOOT" tracing an itermittent horn

    Started by LarrBeard, 03-27-2021 07:15 PM
    2 Attachment(s)
    • Replies: 0
    • Views: 2,711
    LarrBeard
    03-27-2021, 07:15 PM Go to last post

  14. Sticky Thread Sticky: Closed Knuckle and Steering Box Lubrication

    Started by bmorgil, 03-27-2020 07:51 AM
    • Replies: 4
    • Views: 25,767
    bmorgil
    01-18-2021, 04:30 PM Go to last post

  15. Sticky Thread Sticky: Carter YF carburetor info

    Started by Patriot, 11-02-2020 05:39 PM
    carteryf
    • Replies: 5
    • Views: 32,620
    skloetzel
    12-23-2020, 12:43 AM Go to last post

  16. Sticky Thread Sticky: CJ rear drivesahft bind after lifting or new springs

    Started by bmorgil, 08-07-2019 07:16 PM
    3 Attachment(s)
    • Replies: 3
    • Views: 21,703
    gmwillys
    09-28-2020, 10:25 AM Go to last post

  17. Sticky Thread Sticky: Auto-lite Service Parts Catalog

    Started by AmyB, 09-08-2020 08:29 AM
    auto-lite
    • Replies: 0
    • Views: 21,643
    AmyB
    09-08-2020, 08:29 AM Go to last post

  18. Sticky Thread Sticky: Converting an Oil bath Air Cleaner to An Element

    Started by bmorgil, 09-01-2020 05:13 PM
    5 Attachment(s)
    • Replies: 3
    • Views: 10,047
    gmwillys
    09-02-2020, 08:48 AM Go to last post

  19. Sticky Thread Sticky: Vacuum Wiper Motor Teardown, Inspection, Cleaning and Reassembly

    Started by AmyB, 08-18-2020 08:38 AM
    vacuum wiper motor, willys jeep 1 Attachment(s)
    • Replies: 0
    • Views: 9,400
    AmyB
    08-18-2020, 08:38 AM Go to last post

  20. Sticky Thread Sticky: T90 Transmission and Dana 18 Transfer case Lube Levels

    Started by bmorgil, 06-03-2020 07:03 AM
    1 Attachment(s)
    • Replies: 1
    • Views: 16,019
    Carson Childs
    07-20-2020, 11:51 PM Go to last post

  21. Sticky Thread Sticky: The correct lube for a Jeep synchronized transmission

    Started by bmorgil, 01-11-2020 07:21 AM
    • Replies: 3
    • Views: 22,267
    bmorgil
    04-27-2020, 07:23 PM Go to last post

  22. Sticky Thread Sticky: JEEP Serial Numbers, Production Figures, & Models

    Started by bmorgil, 04-10-2020 01:22 PM
    • Replies: 0
    • Views: 11,144
    bmorgil
    04-10-2020, 01:22 PM Go to last post

  23. Sticky Thread Sticky: The M38A1 24 volt ignition system and coil

    Started by bmorgil, 03-29-2020 08:07 PM
    • Replies: 0
    • Views: 11,618
    bmorgil
    03-29-2020, 08:07 PM Go to last post

  24. Sticky Thread Sticky: The Right Motor Oil

    Started by bmorgil, 03-03-2020 08:53 AM
    1 Attachment(s)
    • Replies: 7
    • Views: 18,366
    bmorgil
    03-06-2020, 06:37 PM Go to last post

  25. Sticky Thread Sticky: The Correct Grease for the "Zerks"

    Started by bmorgil, 02-03-2020 06:53 PM
    • Replies: 0
    • Views: 8,917
    bmorgil
    02-03-2020, 06:53 PM Go to last post

  26. Sticky Thread Sticky: 53-71 Service Manual - 4-Wheel Drive CJ-3B, 5, 5A, 6, 6A - 2-Wheel Drive DJ-5, DJ-6

    Started by AmyB, 02-03-2020 11:50 AM
    service manual, willys jeep
    • Replies: 0
    • Views: 5,933
    AmyB
    02-03-2020, 11:50 AM Go to last post

  27. Sticky Thread Sticky: CJ-3A Owners Manual PDFs

    Started by AmyB, 12-30-2019 11:20 AM
    willys cj3a owners manual
    • Replies: 1
    • Views: 20,508
    Dana D
    01-01-2020, 02:54 PM Go to last post

  28. Sticky Thread Sticky: TM9-1804A - Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38

    Started by AmyB, 12-30-2019 11:41 AM
    willys m38 clutch engine
    • Replies: 0
    • Views: 9,571
    AmyB
    12-30-2019, 11:41 AM Go to last post

  29. Sticky Thread Sticky: 5310-3 - Spicer Axle Maintenance Manual - Front and Rear Carrier Type

    Started by AmyB, 12-02-2019 10:19 AM
    axle, dana 44, jeep axle, maintenance manual, spicer
    • Replies: 0
    • Views: 16,359
    AmyB
    12-02-2019, 10:19 AM Go to last post

  30. Sticky Thread Sticky: Spicer Service Manual - Failure Analysis AXSM-0020 Dec 2015

    Started by AmyB, 12-02-2019 10:15 AM
    axles, bearings, gears, service manual, spicer
    • Replies: 0
    • Views: 11,358
    AmyB
    12-02-2019, 10:15 AM Go to last post

  31. Sticky Thread Sticky: How fast is the RPM at speed, or the speed at RPM?

    Started by bmorgil, 10-20-2019 09:15 AM
    • Replies: 0
    • Views: 21,319
    bmorgil
    10-20-2019, 09:15 AM Go to last post

  32. Sticky Thread Sticky: TM9-8015-1: Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38A1

    Started by RachelH, 10-15-2019 08:49 AM
    m38a1 engine clutch
    • Replies: 2
    • Views: 14,471
    RachelH
    10-15-2019, 08:57 AM Go to last post

  33. Sticky Thread Sticky: TM9-8015-2: Power Train Body and Frame for 1/4 Ton 4x4 Utility Truck M38A1

    Started by RachelH, 10-15-2019 08:56 AM
    body, frame, m38a1, power train
    • Replies: 0
    • Views: 12,612
    RachelH
    10-15-2019, 08:56 AM Go to last post

  34. Sticky Thread Sticky: TM9-8014: 1/4 Ton 4x4 Utility Truck M38A1 and 1/4 Ton 4x4 Front Line Ambulance M170

    Started by RachelH, 10-14-2019 09:47 AM
    m38a1 manual
    • Replies: 0
    • Views: 16,406
    RachelH
    10-14-2019, 09:47 AM Go to last post

  35. Sticky Thread Sticky: Oil Bath Air Cleaners 101

    Started by LarrBeard, 08-25-2018 10:07 AM
    4 Attachment(s)
    • Replies: 5
    • Views: 34,129
    LarrBeard
    05-15-2019, 03:06 PM Go to last post

  36. Sticky Thread Sticky: How Do I Set Up An 8-volt Regulator?

    Started by LarrBeard, 04-14-2019 01:27 PM
    1 Attachment(s)
    • Replies: 0
    • Views: 16,775
    LarrBeard
    04-14-2019, 01:27 PM Go to last post

  37. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section II

    Started by LarrBeard, 08-26-2018 02:49 PM
    3 Attachment(s)
    • Replies: 0
    • Views: 26,648
    LarrBeard
    08-26-2018, 02:49 PM Go to last post

  38. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section I

    Started by LarrBeard, 08-26-2018 02:19 PM
    2 Attachment(s)
    • Replies: 0
    • Views: 21,676
    LarrBeard
    08-26-2018, 02:19 PM Go to last post

  39. Sticky Thread Sticky: Old Jeep Generators; An Introduction

    Started by LarrBeard, 08-24-2018 09:22 AM
    1 Attachment(s)
    • Replies: 0
    • Views: 13,770
    LarrBeard
    08-24-2018, 09:22 AM Go to last post

  1. going backwards..

    Started by churchkey, 12-01-2021 08:55 PM
    • Replies: 2
    • Views: 2,388
    churchkey
    12-07-2021, 09:06 PM Go to last post

  2. Wiring Diagram for CJ2A 12V system

    Started by Willys1948, 09-28-2021 11:54 AM
    • Replies: 0
    • Views: 2,764
    Willys1948
    09-28-2021, 11:54 AM Go to last post

  3. Oil Pressure

    Started by The_Green_Bean_59, 03-06-2021 02:50 AM
    oil, pressure
    • Replies: 6
    • Views: 11,118
    LarrBeard
    03-06-2021, 01:36 PM Go to last post

  4. Topping off Trans/Transfer Case fluids, but don't know what's already in there?

    Started by One65r, 07-23-2020 04:37 PM
    2 Pages •
    1 2
    • Replies: 16
    • Views: 35,132
    bmorgil
    10-05-2020, 06:53 PM Go to last post

  5. Diagram of all zerks that need grease on an M38A1?

    Started by One65r, 07-23-2020 04:30 PM
    • Replies: 4
    • Views: 11,386
    Carson Childs
    08-03-2020, 02:50 AM Go to last post

  6. Checking the Manifold Vacuum Pressure … 1958 L6-226

    Started by Jake-1, 04-05-2020 03:51 PM
    l6-226, manifold vacuum
    • Replies: 2
    • Views: 11,491
    Jake-1
    04-06-2020, 05:28 PM Go to last post

  7. Original Carburator?

    Started by Jake-1, 04-05-2020 03:47 PM
    carburator
    • Replies: 0
    • Views: 8,586
    Jake-1
    04-05-2020, 03:47 PM Go to last post

  8. Solex Carburetor Tips and Info:

    Started by AmyB, 08-15-2013 01:42 PM
    carburetor, solex, tech tips, willys jeep
    • Replies: 4
    • Views: 23,470
    LarrBeard
    03-12-2020, 06:57 AM Go to last post

  9. Tranny and Transfer case manuals

    Started by mhead, 02-11-2020 05:41 AM
    • Replies: 1
    • Views: 10,764
    bmorgil
    02-11-2020, 08:28 AM Go to last post

  10. Manual CJ5

    Started by mhead, 12-31-2019 10:37 AM
    • Replies: 1
    • Views: 11,343
    LarrBeard
    12-31-2019, 03:06 PM Go to last post

  11. More on L134 starter gear wont engage, grinds against the flywheel.

    Started by bmorgil, 09-07-2019 05:46 PM
    • Replies: 0
    • Views: 21,163
    bmorgil
    09-07-2019, 05:46 PM Go to last post

  12. CJ-3A starter grinding. Adjusting a CJ-3A Starter Foot Switch

    Started by bmorgil, 08-18-2019 10:38 AM
    5 Attachment(s)
    • Replies: 2
    • Views: 17,491
    bmorgil
    08-19-2019, 07:50 AM Go to last post

  13. Champion Radiator in a CJ3A

    Started by bmorgil, 06-30-2019 09:11 AM
    3 Pages •
    1 2 3
    4 Attachment(s)
    • Replies: 21
    • Views: 74,702
    gmwillys
    07-08-2019, 07:47 PM Go to last post

  14. 12 volt conversion questions

    Started by Jbudd43MB, 04-29-2019 10:04 PM
    12 volt, 1943, 6 volt, timing, willysmb
    • Replies: 0
    • Views: 20,645
    Jbudd43MB
    04-29-2019, 10:04 PM Go to last post

  15. Problemas de encendido

    Started by carl gerard, 02-01-2019 10:43 AM
    • Replies: 1
    • Views: 35,509
    Nemo von Klepper
    02-16-2019, 11:13 PM Go to last post

  16. Presentacion para el grupo y pregunta sobre el encendido

    Started by carl gerard, 02-09-2019 06:37 PM
    problemas de encendido
    • Replies: 3
    • Views: 20,029
    LarrBeard
    02-10-2019, 06:02 PM Go to last post

  17. Original Warn Hub Lock Instructions

    Started by bmorgil, 02-06-2019 12:50 PM
    3 Attachment(s)
    • Replies: 0
    • Views: 16,858
    bmorgil
    02-06-2019, 12:50 PM Go to last post

  18. Three relay Voltage/Current Regulator Video

    Started by LarrBeard, 08-02-2018 07:28 PM
    1 Attachment(s)
    • Replies: 0
    • Views: 18,012
    LarrBeard
    08-02-2018, 07:28 PM Go to last post

  19. Ammeter vs. Volt gauge

    Started by danielbaldwin, 07-11-2018 11:18 AM
    ammeter, electrical gauge, volt meter
    • Replies: 2
    • Views: 25,474
    danielbaldwin
    07-12-2018, 10:21 AM Go to last post

  20. Cooling issues

    Started by Undone, 06-15-2018 08:59 PM
    • Replies: 3
    • Views: 21,047
    gmwillys
    06-21-2018, 10:29 PM Go to last post
Page 1 of 2 12 LastLast

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

Forum Rules