Page 1 of 2 12 LastLast
Threads 1 to 20 of 36

Forum: Tech Library

Post instructions, diagrams, how-to's or anything else you feel would help a fellow Willys or Jeep owner! This is the tech library, so if you'd like to post a tech question, please do so in the "Tech Questions, Answers etc." Forum. Thank you for sharing your knowledge!

  1. Sticky Thread Sticky: Warn Overdrive Manual

    Started by bmorgil, 09-03-2023 06:53 AM
    • Replies: 0
    • Views: 2,111
    09-03-2023, 06:53 AM Go to last post
  2. Sticky Thread Sticky: Start-up Best Practices

    Started by LarrBeard, 06-11-2018 10:45 AM
    2 Pages
    1 2
    • Replies: 18
    • Views: 34,549
    08-01-2023, 10:17 AM Go to last post
  3. Sticky Thread Sticky: The Introduction of the Dana 27

    Started by oblvnnwtnjhn, 02-15-2023 10:59 PM
    • Replies: 5
    • Views: 4,127
    02-25-2023, 09:21 AM Go to last post
  4. Sticky Thread Sticky: Square O-rings for Older Warn Locking Hubs

    Started by test1328, 02-02-2023 02:29 PM
    • Replies: 6
    • Views: 3,600
    02-04-2023, 03:17 AM Go to last post
  5. Sticky Thread Sticky: P.T.O Information

    Started by gmwillys, 02-01-2023 02:01 AM
    • Replies: 0
    • Views: 2,098
    02-01-2023, 02:01 AM Go to last post
  6. Sticky Thread Sticky: Correct Axle Carrier Bearing Cap Torque

    Started by bmorgil, 11-02-2022 03:09 PM
    • Replies: 0
    • Views: 17,670
    11-02-2022, 03:09 PM Go to last post
  7. Sticky Thread Sticky: A New Piston Choice for the L134 & F134

    Started by bmorgil, 10-29-2022 07:59 AM
    • Replies: 1
    • Views: 2,997
    10-31-2022, 12:17 AM Go to last post
  8. Sticky Thread Sticky: Obtaining / Setting a Ring and Pinion Gear Pattern

    Started by Wulfie, 07-11-2022 08:03 PM
    3 Pages
    1 2 3
    • Replies: 25
    • Views: 15,154
    07-27-2022, 06:13 AM Go to last post
    • Replies: 5
    • Views: 6,620
    04-20-2022, 04:32 PM Go to last post
  9. Sticky Thread Sticky: Unleadead fuel in your Classic

    Started by bmorgil, 08-03-2021 04:42 PM
    • Replies: 1
    • Views: 5,041
    08-04-2021, 12:57 AM Go to last post
  10. Sticky Thread Sticky: T90 Teardown Important Correction to Rick Stivers Guide

    Started by bmorgil, 08-01-2021 11:25 AM
    • Replies: 1
    • Views: 4,990
    08-01-2021, 12:13 PM Go to last post
  11. Sticky Thread Sticky: CJ-2 through CJ-6 fuel pumps and pressures

    Started by bmorgil, 05-26-2021 06:14 AM
    • Replies: 0
    • Views: 4,698
    05-26-2021, 06:14 AM Go to last post
  12. Sticky Thread Sticky: Speedi Sleeve for MB Axle

    Started by LTjackMB41, 04-12-2021 11:35 AM
    • Replies: 2
    • Views: 11,259
    04-12-2021, 02:03 PM Go to last post
  13. Sticky Thread Sticky: Make it go "HOOT" tracing an itermittent horn

    Started by LarrBeard, 03-27-2021 07:15 PM
    • Replies: 0
    • Views: 8,648
    03-27-2021, 07:15 PM Go to last post
  14. Sticky Thread Sticky: Closed Knuckle and Steering Box Lubrication

    Started by bmorgil, 03-27-2020 07:51 AM
    • Replies: 3
    • Views: 42,154
    01-18-2021, 04:30 PM Go to last post
  15. Sticky Thread Sticky: Carter YF carburetor info

    Started by Patriot, 11-02-2020 05:39 PM
    carteryf
    • Replies: 5
    • Views: 42,064
    12-23-2020, 12:43 AM Go to last post
  16. Sticky Thread Sticky: CJ rear drivesahft bind after lifting or new springs

    Started by bmorgil, 08-07-2019 07:16 PM
    • Replies: 3
    • Views: 27,577
    09-28-2020, 10:25 AM Go to last post
  17. Sticky Thread Sticky: Auto-lite Service Parts Catalog

    Started by AmyB, 09-08-2020 08:29 AM
    auto-lite
    • Replies: 0
    • Views: 29,587
    09-08-2020, 08:29 AM Go to last post
  18. Sticky Thread Sticky: Converting an Oil bath Air Cleaner to An Element

    Started by bmorgil, 09-01-2020 05:13 PM
    • Replies: 3
    • Views: 13,239
    09-02-2020, 08:48 AM Go to last post
    • Replies: 0
    • Views: 12,492
    08-18-2020, 08:38 AM Go to last post
  19. Sticky Thread Sticky: T90 Transmission and Dana 18 Transfer case Lube Levels

    Started by bmorgil, 06-03-2020 07:03 AM
    • Replies: 1
    • Views: 20,479
    07-20-2020, 11:51 PM Go to last post
  20. Sticky Thread Sticky: The correct lube for a Jeep synchronized transmission

    Started by bmorgil, 01-11-2020 07:21 AM
    • Replies: 3
    • Views: 27,567
    04-27-2020, 07:23 PM Go to last post
  21. Sticky Thread Sticky: JEEP Serial Numbers, Production Figures, & Models

    Started by bmorgil, 04-10-2020 01:22 PM
    • Replies: 0
    • Views: 14,289
    04-10-2020, 01:22 PM Go to last post
  22. Sticky Thread Sticky: The M38A1 24 volt ignition system and coil

    Started by bmorgil, 03-29-2020 08:07 PM
    • Replies: 0
    • Views: 15,552
    03-29-2020, 08:07 PM Go to last post
  23. Sticky Thread Sticky: The Right Motor Oil

    Started by bmorgil, 03-03-2020 08:53 AM
    • Replies: 7
    • Views: 22,533
    03-06-2020, 06:37 PM Go to last post
  24. Sticky Thread Sticky: The Correct Grease for the "Zerks"

    Started by bmorgil, 02-03-2020 06:53 PM
    • Replies: 0
    • Views: 11,531
    02-03-2020, 06:53 PM Go to last post
    • Replies: 0
    • Views: 8,195
    02-03-2020, 11:50 AM Go to last post
  25. Sticky Thread Sticky: CJ-3A Owners Manual PDFs

    Started by AmyB, 12-30-2019 11:20 AM
    willys cj3a owners manual
    • Replies: 1
    • Views: 26,358
    01-01-2020, 02:54 PM Go to last post
  26. Sticky Thread Sticky: TM9-1804A - Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38

    Started by AmyB, 12-30-2019 11:41 AM
    willys m38 clutch engine
    • Replies: 0
    • Views: 12,420
    12-30-2019, 11:41 AM Go to last post
    • Replies: 0
    • Views: 26,876
    12-02-2019, 10:19 AM Go to last post
  27. Sticky Thread Sticky: Spicer Service Manual - Failure Analysis AXSM-0020 Dec 2015

    Started by AmyB, 12-02-2019 10:15 AM
    axles, bearings, gears, service manual, spicer
    • Replies: 0
    • Views: 28,459
    12-02-2019, 10:15 AM Go to last post
  28. Sticky Thread Sticky: How fast is the RPM at speed, or the speed at RPM?

    Started by bmorgil, 10-20-2019 09:15 AM
    • Replies: 0
    • Views: 26,949
    10-20-2019, 09:15 AM Go to last post
    • Replies: 2
    • Views: 18,680
    10-15-2019, 08:57 AM Go to last post
    • Replies: 0
    • Views: 17,523
    10-15-2019, 08:56 AM Go to last post
    • Replies: 0
    • Views: 21,256
    10-14-2019, 09:47 AM Go to last post
  29. Sticky Thread Sticky: Oil Bath Air Cleaners 101

    Started by LarrBeard, 08-25-2018 10:07 AM
    • Replies: 5
    • Views: 42,194
    05-15-2019, 03:06 PM Go to last post
  30. Sticky Thread Sticky: How Do I Set Up An 8-volt Regulator?

    Started by LarrBeard, 04-14-2019 01:27 PM
    • Replies: 0
    • Views: 32,212
    04-14-2019, 01:27 PM Go to last post
  31. Sticky Thread Sticky: Original Warn Hub Lock Instructions

    Started by bmorgil, 02-06-2019 12:50 PM
    • Replies: 0
    • Views: 21,129
    02-06-2019, 12:50 PM Go to last post
  32. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section II

    Started by LarrBeard, 08-26-2018 02:49 PM
    • Replies: 0
    • Views: 32,781
    08-26-2018, 02:49 PM Go to last post
  33. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section I

    Started by LarrBeard, 08-26-2018 02:19 PM
    • Replies: 0
    • Views: 26,634
    08-26-2018, 02:19 PM Go to last post
  34. Sticky Thread Sticky: Old Jeep Generators; An Introduction

    Started by LarrBeard, 08-24-2018 09:22 AM
    • Replies: 0
    • Views: 17,353
    08-24-2018, 09:22 AM Go to last post
  1. Cool willys books, pamphlets etc.

    Started by 56willys, 10-03-2023 07:31 PM
    • Replies: 6
    • Views: 9,891
    10-06-2023, 08:27 AM Go to last post
  2. going backwards..

    Started by churchkey, 12-01-2021 08:55 PM
    • Replies: 2
    • Views: 4,066
    12-07-2021, 09:06 PM Go to last post
  3. Wiring Diagram for CJ2A 12V system

    Started by Willys1948, 09-28-2021 11:54 AM
    • Replies: 0
    • Views: 4,083
    09-28-2021, 11:54 AM Go to last post
  4. Oil Pressure

    Started by The_Green_Bean_59, 03-06-2021 02:50 AM
    oil, pressure
    • Replies: 6
    • Views: 15,639
    03-06-2021, 01:36 PM Go to last post
    • Replies: 16
    • Views: 49,599
    10-05-2020, 06:53 PM Go to last post
  5. Diagram of all zerks that need grease on an M38A1?

    Started by One65r, 07-23-2020 04:30 PM
    • Replies: 4
    • Views: 14,947
    08-03-2020, 02:50 AM Go to last post
    • Replies: 2
    • Views: 14,863
    04-06-2020, 05:28 PM Go to last post
  6. Original Carburator?

    Started by Jake-1, 04-05-2020 03:47 PM
    carburator
    • Replies: 0
    • Views: 11,334
    04-05-2020, 03:47 PM Go to last post
  7. Solex Carburetor Tips and Info:

    Started by AmyB, 08-15-2013 01:42 PM
    carburetor, solex, tech tips, willys jeep
    • Replies: 4
    • Views: 27,586
    03-12-2020, 06:57 AM Go to last post
  8. Tranny and Transfer case manuals

    Started by mhead, 02-11-2020 05:41 AM
    • Replies: 1
    • Views: 13,324
    02-11-2020, 08:28 AM Go to last post
  9. Manual CJ5

    Started by mhead, 12-31-2019 10:37 AM
    • Replies: 1
    • Views: 14,709
    12-31-2019, 03:06 PM Go to last post
    • Replies: 0
    • Views: 26,875
    09-07-2019, 05:46 PM Go to last post
    • Replies: 2
    • Views: 22,347
    08-19-2019, 07:50 AM Go to last post
  10. Champion Radiator in a CJ3A

    Started by bmorgil, 06-30-2019 09:11 AM
    3 Pages
    1 2 3
    • Replies: 21
    • Views: 98,434
    07-08-2019, 07:47 PM Go to last post
  11. 12 volt conversion questions

    Started by Jbudd43MB, 04-29-2019 10:04 PM
    12 volt, 1943, 6 volt, timing, willysmb
    • Replies: 0
    • Views: 26,509
    04-29-2019, 10:04 PM Go to last post
  12. Problemas de encendido

    Started by carl gerard, 02-01-2019 10:43 AM
    • Replies: 1
    • Views: 44,763
    02-16-2019, 11:13 PM Go to last post
    • Replies: 3
    • Views: 25,012
    02-10-2019, 06:02 PM Go to last post
  13. Three relay Voltage/Current Regulator Video

    Started by LarrBeard, 08-02-2018 07:28 PM
    • Replies: 0
    • Views: 23,020
    08-02-2018, 07:28 PM Go to last post
  14. Ammeter vs. Volt gauge

    Started by danielbaldwin, 07-11-2018 11:18 AM
    ammeter, electrical gauge, volt meter
    • Replies: 2
    • Views: 32,446
    07-12-2018, 10:21 AM Go to last post
  15. Cooling issues

    Started by Undone, 06-15-2018 08:59 PM
    • Replies: 3
    • Views: 26,914
    06-21-2018, 10:29 PM Go to last post

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •