Page 1 of 2 12 LastLast
Threads 1 to 20 of 33

Forum: Tech Library

Post instructions, diagrams, how-to's or anything else you feel would help a fellow Willys or Jeep owner! This is the tech library, so if you'd like to post a tech question, please do so in the "Tech Questions, Answers etc." Forum. Thank you for sharing your knowledge!

  1. Sticky Thread Sticky: The Correct Grease for the "Zerks"

    Started by bmorgil, 02-03-2020 06:53 PM
    • Replies: 1
    • Views: 17,121
    05-24-2024, 08:31 AM Go to last post
  2. Sticky Thread Sticky: Warn Overdrive Manual

    Started by bmorgil, 09-03-2023 06:53 AM
    • Replies: 0
    • Views: 3,270
    09-03-2023, 06:53 AM Go to last post
  3. Sticky Thread Sticky: Start-up Best Practices

    Started by LarrBeard, 06-11-2018 10:45 AM
    2 Pages
    1 2
    • Replies: 18
    • Views: 39,536
    08-01-2023, 10:17 AM Go to last post
  4. Sticky Thread Sticky: The Introduction of the Dana 27

    Started by oblvnnwtnjhn, 02-15-2023 10:59 PM
    • Replies: 5
    • Views: 5,717
    02-25-2023, 09:21 AM Go to last post
  5. Sticky Thread Sticky: Square O-rings for Older Warn Locking Hubs

    Started by test1328, 02-02-2023 02:29 PM
    • Replies: 6
    • Views: 4,995
    02-04-2023, 03:17 AM Go to last post
  6. Sticky Thread Sticky: P.T.O Information

    Started by gmwillys, 02-01-2023 02:01 AM
    • Replies: 0
    • Views: 3,137
    02-01-2023, 02:01 AM Go to last post
  7. Sticky Thread Sticky: Correct Axle Carrier Bearing Cap Torque

    Started by bmorgil, 11-02-2022 03:09 PM
    • Replies: 0
    • Views: 18,834
    11-02-2022, 03:09 PM Go to last post
  8. Sticky Thread Sticky: A New Piston Choice for the L134 & F134

    Started by bmorgil, 10-29-2022 07:59 AM
    • Replies: 1
    • Views: 4,078
    10-31-2022, 12:17 AM Go to last post
  9. Sticky Thread Sticky: Neoprene Rear Main Oil Seal

    Started by 1987J20, 09-21-2022 05:51 AM
    • Replies: 5
    • Views: 4,347
    09-22-2022, 08:43 AM Go to last post
  10. Sticky Thread Sticky: Obtaining / Setting a Ring and Pinion Gear Pattern

    Started by Wulfie, 07-11-2022 08:03 PM
    3 Pages
    1 2 3
    • Replies: 25
    • Views: 18,160
    07-27-2022, 06:13 AM Go to last post
    • Replies: 5
    • Views: 8,439
    04-20-2022, 04:32 PM Go to last post
  11. Sticky Thread Sticky: Unleadead fuel in your Classic

    Started by bmorgil, 08-03-2021 04:42 PM
    • Replies: 1
    • Views: 6,354
    08-04-2021, 12:57 AM Go to last post
  12. Sticky Thread Sticky: T90 Teardown Important Correction to Rick Stivers Guide

    Started by bmorgil, 08-01-2021 11:25 AM
    • Replies: 1
    • Views: 6,239
    08-01-2021, 12:13 PM Go to last post
  13. Sticky Thread Sticky: CJ-2 through CJ-6 fuel pumps and pressures

    Started by bmorgil, 05-26-2021 06:14 AM
    • Replies: 0
    • Views: 6,011
    05-26-2021, 06:14 AM Go to last post
  14. Sticky Thread Sticky: Speedi Sleeve for MB Axle

    Started by LTjackMB41, 04-12-2021 11:35 AM
    • Replies: 2
    • Views: 13,101
    04-12-2021, 02:03 PM Go to last post
  15. Sticky Thread Sticky: Make it go "HOOT" tracing an itermittent horn

    Started by LarrBeard, 03-27-2021 07:15 PM
    • Replies: 0
    • Views: 10,048
    03-27-2021, 07:15 PM Go to last post
  16. Sticky Thread Sticky: Closed Knuckle and Steering Box Lubrication

    Started by bmorgil, 03-27-2020 07:51 AM
    • Replies: 3
    • Views: 45,810
    01-18-2021, 04:30 PM Go to last post
  17. Sticky Thread Sticky: Carter YF carburetor info

    Started by Patriot, 11-02-2020 05:39 PM
    carteryf
    • Replies: 5
    • Views: 45,516
    12-23-2020, 12:43 AM Go to last post
  18. Sticky Thread Sticky: CJ rear drivesahft bind after lifting or new springs

    Started by bmorgil, 08-07-2019 07:16 PM
    • Replies: 3
    • Views: 31,002
    09-28-2020, 10:25 AM Go to last post
  19. Sticky Thread Sticky: Auto-lite Service Parts Catalog

    Started by AmyB, 09-08-2020 08:29 AM
    auto-lite
    • Replies: 0
    • Views: 33,727
    09-08-2020, 08:29 AM Go to last post
  20. Sticky Thread Sticky: Converting an Oil bath Air Cleaner to An Element

    Started by bmorgil, 09-01-2020 05:13 PM
    • Replies: 3
    • Views: 15,462
    09-02-2020, 08:48 AM Go to last post
    • Replies: 0
    • Views: 14,811
    08-18-2020, 08:38 AM Go to last post
  21. Sticky Thread Sticky: T90 Transmission and Dana 18 Transfer case Lube Levels

    Started by bmorgil, 06-03-2020 07:03 AM
    • Replies: 1
    • Views: 23,113
    07-20-2020, 11:51 PM Go to last post
  22. Sticky Thread Sticky: The correct lube for a Jeep synchronized transmission

    Started by bmorgil, 01-11-2020 07:21 AM
    • Replies: 3
    • Views: 30,752
    04-27-2020, 07:23 PM Go to last post
  23. Sticky Thread Sticky: JEEP Serial Numbers, Production Figures, & Models

    Started by bmorgil, 04-10-2020 01:22 PM
    • Replies: 0
    • Views: 16,559
    04-10-2020, 01:22 PM Go to last post
  24. Sticky Thread Sticky: The M38A1 24 volt ignition system and coil

    Started by bmorgil, 03-29-2020 08:07 PM
    • Replies: 0
    • Views: 18,185
    03-29-2020, 08:07 PM Go to last post
  25. Sticky Thread Sticky: Solex Carburetor Tips and Info:

    Started by AmyB, 08-15-2013 01:42 PM
    carburetor, solex, tech tips, willys jeep
    • Replies: 3
    • Views: 31,572
    03-12-2020, 06:57 AM Go to last post
  26. Sticky Thread Sticky: The Right Motor Oil

    Started by bmorgil, 03-03-2020 08:53 AM
    • Replies: 7
    • Views: 25,610
    03-06-2020, 06:37 PM Go to last post
  27. Sticky Thread Sticky: Sodium vs Lithium, Wheel Bearings

    Started by bozoli, 02-13-2020 11:28 PM
    • Replies: 3
    • Views: 7,029
    02-14-2020, 08:07 PM Go to last post
    • Replies: 0
    • Views: 11,205
    02-03-2020, 11:50 AM Go to last post
  28. Sticky Thread Sticky: CJ-3A Owners Manual PDFs

    Started by AmyB, 12-30-2019 11:20 AM
    willys cj3a owners manual
    • Replies: 1
    • Views: 29,649
    01-01-2020, 02:54 PM Go to last post
  29. Sticky Thread Sticky: TM9-1804A - Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38

    Started by AmyB, 12-30-2019 11:41 AM
    willys m38 clutch engine
    • Replies: 0
    • Views: 15,058
    12-30-2019, 11:41 AM Go to last post
    • Replies: 0
    • Views: 30,602
    12-02-2019, 10:19 AM Go to last post
  30. Sticky Thread Sticky: Spicer Service Manual - Failure Analysis AXSM-0020 Dec 2015

    Started by AmyB, 12-02-2019 10:15 AM
    axles, bearings, gears, service manual, spicer
    • Replies: 0
    • Views: 32,772
    12-02-2019, 10:15 AM Go to last post
  31. Sticky Thread Sticky: How fast is the RPM at speed, or the speed at RPM?

    Started by bmorgil, 10-20-2019 09:15 AM
    • Replies: 0
    • Views: 30,018
    10-20-2019, 09:15 AM Go to last post
    • Replies: 2
    • Views: 23,686
    10-15-2019, 08:57 AM Go to last post
    • Replies: 0
    • Views: 22,556
    10-15-2019, 08:56 AM Go to last post
    • Replies: 0
    • Views: 25,307
    10-14-2019, 09:47 AM Go to last post
    • Replies: 0
    • Views: 29,902
    09-07-2019, 05:46 PM Go to last post
    • Replies: 2
    • Views: 25,418
    08-19-2019, 07:50 AM Go to last post
  32. Sticky Thread Sticky: Oil Bath Air Cleaners 101

    Started by LarrBeard, 08-25-2018 10:07 AM
    • Replies: 5
    • Views: 47,023
    05-15-2019, 03:06 PM Go to last post
  33. Sticky Thread Sticky: How Do I Set Up An 8-volt Regulator?

    Started by LarrBeard, 04-14-2019 01:27 PM
    • Replies: 0
    • Views: 35,269
    04-14-2019, 01:27 PM Go to last post
  34. Sticky Thread Sticky: Original Warn Hub Lock Instructions

    Started by bmorgil, 02-06-2019 12:50 PM
    • Replies: 0
    • Views: 23,986
    02-06-2019, 12:50 PM Go to last post
  35. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section II

    Started by LarrBeard, 08-26-2018 02:49 PM
    • Replies: 0
    • Views: 35,878
    08-26-2018, 02:49 PM Go to last post
  36. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section I

    Started by LarrBeard, 08-26-2018 02:19 PM
    • Replies: 0
    • Views: 29,490
    08-26-2018, 02:19 PM Go to last post
  37. Sticky Thread Sticky: Old Jeep Generators; An Introduction

    Started by LarrBeard, 08-24-2018 09:22 AM
    • Replies: 0
    • Views: 19,943
    08-24-2018, 09:22 AM Go to last post
  1. Cool willys books, pamphlets etc.

    Started by 56willys, 10-03-2023 07:31 PM
    • Replies: 6
    • Views: 46,088
    10-06-2023, 08:27 AM Go to last post
  2. going backwards..

    Started by churchkey, 12-01-2021 08:55 PM
    • Replies: 2
    • Views: 5,469
    12-07-2021, 09:06 PM Go to last post
  3. Wiring Diagram for CJ2A 12V system

    Started by Willys1948, 09-28-2021 11:54 AM
    • Replies: 0
    • Views: 5,131
    09-28-2021, 11:54 AM Go to last post
  4. Oil Pressure

    Started by The_Green_Bean_59, 03-06-2021 02:50 AM
    oil, pressure
    • Replies: 6
    • Views: 18,107
    03-06-2021, 01:36 PM Go to last post
    • Replies: 16
    • Views: 54,131
    10-05-2020, 06:53 PM Go to last post
  5. Diagram of all zerks that need grease on an M38A1?

    Started by One65r, 07-23-2020 04:30 PM
    • Replies: 4
    • Views: 17,421
    08-03-2020, 02:50 AM Go to last post
    • Replies: 2
    • Views: 18,071
    04-06-2020, 05:28 PM Go to last post
  6. Original Carburator?

    Started by Jake-1, 04-05-2020 03:47 PM
    carburator
    • Replies: 0
    • Views: 13,303
    04-05-2020, 03:47 PM Go to last post
  7. Tranny and Transfer case manuals

    Started by mhead, 02-11-2020 05:41 AM
    • Replies: 1
    • Views: 15,515
    02-11-2020, 08:28 AM Go to last post
  8. Manual CJ5

    Started by mhead, 12-31-2019 10:37 AM
    • Replies: 1
    • Views: 17,191
    12-31-2019, 03:06 PM Go to last post
  9. Champion Radiator in a CJ3A

    Started by bmorgil, 06-30-2019 09:11 AM
    3 Pages
    1 2 3
    • Replies: 21
    • Views: 106,694
    07-08-2019, 07:47 PM Go to last post
  10. 12 volt conversion questions

    Started by Jbudd43MB, 04-29-2019 10:04 PM
    12 volt, 1943, 6 volt, timing, willysmb
    • Replies: 0
    • Views: 30,701
    04-29-2019, 10:04 PM Go to last post
  11. Problemas de encendido

    Started by carl gerard, 02-01-2019 10:43 AM
    • Replies: 1
    • Views: 48,454
    02-16-2019, 11:13 PM Go to last post
    • Replies: 3
    • Views: 28,761
    02-10-2019, 06:02 PM Go to last post
  12. Three relay Voltage/Current Regulator Video

    Started by LarrBeard, 08-02-2018 07:28 PM
    • Replies: 0
    • Views: 25,430
    08-02-2018, 07:28 PM Go to last post
  13. Ammeter vs. Volt gauge

    Started by danielbaldwin, 07-11-2018 11:18 AM
    ammeter, electrical gauge, volt meter
    • Replies: 2
    • Views: 36,342
    07-12-2018, 10:21 AM Go to last post
  14. Cooling issues

    Started by Undone, 06-15-2018 08:59 PM
    • Replies: 3
    • Views: 29,316
    06-21-2018, 10:29 PM Go to last post
  15. Need help with 52' M38

    Started by ghillie, 05-18-2018 08:18 AM
    • Replies: 0
    • Views: 32,950
    05-18-2018, 08:18 AM Go to last post
  16. Fuel Pump

    Started by harte, 05-16-2018 03:34 PM
    • Replies: 5
    • Views: 18,797
    05-17-2018, 03:26 PM Go to last post
    • Replies: 5
    • Views: 8,930
    04-11-2018, 08:08 AM Go to last post

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •