Page 2 of 2 FirstFirst 12
Threads 21 to 33 of 33

Forum: Tech Library

Post instructions, diagrams, how-to's or anything else you feel would help a fellow Willys or Jeep owner! This is the tech library, so if you'd like to post a tech question, please do so in the "Tech Questions, Answers etc." Forum. Thank you for sharing your knowledge!

  1. Sticky Thread Sticky: Warn Overdrive Manual

    Started by bmorgil, 09-03-2023 06:53 AM
    • Replies: 0
    • Views: 2,300
    bmorgil
    09-03-2023, 06:53 AM Go to last post

  2. Sticky Thread Sticky: Start-up Best Practices

    Started by LarrBeard, 06-11-2018 10:45 AM
    2 Pages •
    1 2
    1 Attachment(s)
    • Replies: 18
    • Views: 35,473
    LarrBeard
    08-01-2023, 10:17 AM Go to last post

  3. Sticky Thread Sticky: The Introduction of the Dana 27

    Started by oblvnnwtnjhn, 02-15-2023 10:59 PM
    3 Attachment(s)
    • Replies: 5
    • Views: 4,344
    bmorgil
    02-25-2023, 09:21 AM Go to last post

  4. Sticky Thread Sticky: Square O-rings for Older Warn Locking Hubs

    Started by test1328, 02-02-2023 02:29 PM
    4 Attachment(s)
    • Replies: 6
    • Views: 3,808
    gmwillys
    02-04-2023, 03:17 AM Go to last post

  5. Sticky Thread Sticky: P.T.O Information

    Started by gmwillys, 02-01-2023 02:01 AM
    • Replies: 0
    • Views: 2,193
    gmwillys
    02-01-2023, 02:01 AM Go to last post

  6. Sticky Thread Sticky: Correct Axle Carrier Bearing Cap Torque

    Started by bmorgil, 11-02-2022 03:09 PM
    • Replies: 0
    • Views: 17,824
    bmorgil
    11-02-2022, 03:09 PM Go to last post

  7. Sticky Thread Sticky: A New Piston Choice for the L134 & F134

    Started by bmorgil, 10-29-2022 07:59 AM
    • Replies: 1
    • Views: 3,144
    gmwillys
    10-31-2022, 12:17 AM Go to last post

  8. Sticky Thread Sticky: Obtaining / Setting a Ring and Pinion Gear Pattern

    Started by Wulfie, 07-11-2022 08:03 PM
    3 Pages •
    1 2 3
    12 Attachment(s)
    • Replies: 25
    • Views: 15,503
    bmorgil
    07-27-2022, 06:13 AM Go to last post

  9. Sticky Thread Sticky: Differences between L 134 front engine plate and F 134 front engine plate

    Started by Wulfie, 04-19-2022 09:49 PM
    3 Attachment(s)
    • Replies: 5
    • Views: 7,076
    LarrBeard
    04-20-2022, 04:32 PM Go to last post

  10. Sticky Thread Sticky: Unleadead fuel in your Classic

    Started by bmorgil, 08-03-2021 04:42 PM
    • Replies: 1
    • Views: 5,333
    5JeepsAz
    08-04-2021, 12:57 AM Go to last post

  11. Sticky Thread Sticky: T90 Teardown Important Correction to Rick Stivers Guide

    Started by bmorgil, 08-01-2021 11:25 AM
    1 Attachment(s)
    • Replies: 1
    • Views: 5,248
    5JeepsAz
    08-01-2021, 12:13 PM Go to last post

  12. Sticky Thread Sticky: CJ-2 through CJ-6 fuel pumps and pressures

    Started by bmorgil, 05-26-2021 06:14 AM
    • Replies: 0
    • Views: 5,012
    bmorgil
    05-26-2021, 06:14 AM Go to last post

  13. Sticky Thread Sticky: Speedi Sleeve for MB Axle

    Started by LTjackMB41, 04-12-2021 11:35 AM
    mb axle seal. 1 Attachment(s)
    • Replies: 2
    • Views: 11,769
    gmwillys
    04-12-2021, 02:03 PM Go to last post

  14. Sticky Thread Sticky: Make it go "HOOT" tracing an itermittent horn

    Started by LarrBeard, 03-27-2021 07:15 PM
    2 Attachment(s)
    • Replies: 0
    • Views: 9,019
    LarrBeard
    03-27-2021, 07:15 PM Go to last post

  15. Sticky Thread Sticky: Closed Knuckle and Steering Box Lubrication

    Started by bmorgil, 03-27-2020 07:51 AM
    • Replies: 3
    • Views: 43,569
    bmorgil
    01-18-2021, 04:30 PM Go to last post

  16. Sticky Thread Sticky: Carter YF carburetor info

    Started by Patriot, 11-02-2020 05:39 PM
    carteryf
    • Replies: 5
    • Views: 43,105
    skloetzel
    12-23-2020, 12:43 AM Go to last post

  17. Sticky Thread Sticky: CJ rear drivesahft bind after lifting or new springs

    Started by bmorgil, 08-07-2019 07:16 PM
    3 Attachment(s)
    • Replies: 3
    • Views: 28,955
    gmwillys
    09-28-2020, 10:25 AM Go to last post

  18. Sticky Thread Sticky: Auto-lite Service Parts Catalog

    Started by AmyB, 09-08-2020 08:29 AM
    auto-lite
    • Replies: 0
    • Views: 31,057
    AmyB
    09-08-2020, 08:29 AM Go to last post

  19. Sticky Thread Sticky: Converting an Oil bath Air Cleaner to An Element

    Started by bmorgil, 09-01-2020 05:13 PM
    5 Attachment(s)
    • Replies: 3
    • Views: 13,948
    gmwillys
    09-02-2020, 08:48 AM Go to last post

  20. Sticky Thread Sticky: Vacuum Wiper Motor Teardown, Inspection, Cleaning and Reassembly

    Started by AmyB, 08-18-2020 08:38 AM
    vacuum wiper motor, willys jeep 1 Attachment(s)
    • Replies: 0
    • Views: 13,301
    AmyB
    08-18-2020, 08:38 AM Go to last post

  21. Sticky Thread Sticky: T90 Transmission and Dana 18 Transfer case Lube Levels

    Started by bmorgil, 06-03-2020 07:03 AM
    1 Attachment(s)
    • Replies: 1
    • Views: 21,475
    Carson Childs
    07-20-2020, 11:51 PM Go to last post

  22. Sticky Thread Sticky: The correct lube for a Jeep synchronized transmission

    Started by bmorgil, 01-11-2020 07:21 AM
    • Replies: 3
    • Views: 28,792
    bmorgil
    04-27-2020, 07:23 PM Go to last post

  23. Sticky Thread Sticky: JEEP Serial Numbers, Production Figures, & Models

    Started by bmorgil, 04-10-2020 01:22 PM
    • Replies: 0
    • Views: 15,138
    bmorgil
    04-10-2020, 01:22 PM Go to last post

  24. Sticky Thread Sticky: The M38A1 24 volt ignition system and coil

    Started by bmorgil, 03-29-2020 08:07 PM
    • Replies: 0
    • Views: 16,560
    bmorgil
    03-29-2020, 08:07 PM Go to last post

  25. Sticky Thread Sticky: Solex Carburetor Tips and Info:

    Started by AmyB, 08-15-2013 01:42 PM
    carburetor, solex, tech tips, willys jeep
    • Replies: 3
    • Views: 29,014
    LarrBeard
    03-12-2020, 06:57 AM Go to last post

  26. Sticky Thread Sticky: The Right Motor Oil

    Started by bmorgil, 03-03-2020 08:53 AM
    1 Attachment(s)
    • Replies: 7
    • Views: 23,523
    bmorgil
    03-06-2020, 06:37 PM Go to last post

  27. Sticky Thread Sticky: The Correct Grease for the "Zerks"

    Started by bmorgil, 02-03-2020 06:53 PM
    • Replies: 0
    • Views: 12,471
    bmorgil
    02-03-2020, 06:53 PM Go to last post

  28. Sticky Thread Sticky: 53-71 Service Manual - 4-Wheel Drive CJ-3B, 5, 5A, 6, 6A - 2-Wheel Drive DJ-5, DJ-6

    Started by AmyB, 02-03-2020 11:50 AM
    service manual, willys jeep
    • Replies: 0
    • Views: 9,461
    AmyB
    02-03-2020, 11:50 AM Go to last post

  29. Sticky Thread Sticky: CJ-3A Owners Manual PDFs

    Started by AmyB, 12-30-2019 11:20 AM
    willys cj3a owners manual
    • Replies: 1
    • Views: 27,647
    Dana D
    01-01-2020, 02:54 PM Go to last post

  30. Sticky Thread Sticky: TM9-1804A - Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38

    Started by AmyB, 12-30-2019 11:41 AM
    willys m38 clutch engine
    • Replies: 0
    • Views: 13,567
    AmyB
    12-30-2019, 11:41 AM Go to last post

  31. Sticky Thread Sticky: 5310-3 - Spicer Axle Maintenance Manual - Front and Rear Carrier Type

    Started by AmyB, 12-02-2019 10:19 AM
    axle, dana 44, jeep axle, maintenance manual, spicer
    • Replies: 0
    • Views: 28,403
    AmyB
    12-02-2019, 10:19 AM Go to last post

  32. Sticky Thread Sticky: Spicer Service Manual - Failure Analysis AXSM-0020 Dec 2015

    Started by AmyB, 12-02-2019 10:15 AM
    axles, bearings, gears, service manual, spicer
    • Replies: 0
    • Views: 29,931
    AmyB
    12-02-2019, 10:15 AM Go to last post

  33. Sticky Thread Sticky: How fast is the RPM at speed, or the speed at RPM?

    Started by bmorgil, 10-20-2019 09:15 AM
    • Replies: 0
    • Views: 28,199
    bmorgil
    10-20-2019, 09:15 AM Go to last post

  34. Sticky Thread Sticky: TM9-8015-1: Engine and Clutch for 1/4 Ton 4x4 Utility Truck M38A1

    Started by RachelH, 10-15-2019 08:49 AM
    m38a1 engine clutch
    • Replies: 2
    • Views: 20,200
    RachelH
    10-15-2019, 08:57 AM Go to last post

  35. Sticky Thread Sticky: TM9-8015-2: Power Train Body and Frame for 1/4 Ton 4x4 Utility Truck M38A1

    Started by RachelH, 10-15-2019 08:56 AM
    body, frame, m38a1, power train
    • Replies: 0
    • Views: 19,228
    RachelH
    10-15-2019, 08:56 AM Go to last post

  36. Sticky Thread Sticky: TM9-8014: 1/4 Ton 4x4 Utility Truck M38A1 and 1/4 Ton 4x4 Front Line Ambulance M170

    Started by RachelH, 10-14-2019 09:47 AM
    m38a1 manual
    • Replies: 0
    • Views: 22,666
    RachelH
    10-14-2019, 09:47 AM Go to last post

  37. Sticky Thread Sticky: More on L134 starter gear wont engage, grinds against the flywheel.

    Started by bmorgil, 09-07-2019 05:46 PM
    • Replies: 0
    • Views: 28,119
    bmorgil
    09-07-2019, 05:46 PM Go to last post

  38. Sticky Thread Sticky: CJ-3A starter grinding. Adjusting a CJ-3A Starter Foot Switch

    Started by bmorgil, 08-18-2019 10:38 AM
    5 Attachment(s)
    • Replies: 2
    • Views: 23,606
    bmorgil
    08-19-2019, 07:50 AM Go to last post

  39. Sticky Thread Sticky: Oil Bath Air Cleaners 101

    Started by LarrBeard, 08-25-2018 10:07 AM
    4 Attachment(s)
    • Replies: 5
    • Views: 44,140
    LarrBeard
    05-15-2019, 03:06 PM Go to last post

  40. Sticky Thread Sticky: How Do I Set Up An 8-volt Regulator?

    Started by LarrBeard, 04-14-2019 01:27 PM
    1 Attachment(s)
    • Replies: 0
    • Views: 33,505
    LarrBeard
    04-14-2019, 01:27 PM Go to last post

  41. Sticky Thread Sticky: Original Warn Hub Lock Instructions

    Started by bmorgil, 02-06-2019 12:50 PM
    3 Attachment(s)
    • Replies: 0
    • Views: 22,360
    bmorgil
    02-06-2019, 12:50 PM Go to last post

  42. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section II

    Started by LarrBeard, 08-26-2018 02:49 PM
    3 Attachment(s)
    • Replies: 0
    • Views: 34,029
    LarrBeard
    08-26-2018, 02:49 PM Go to last post

  43. Sticky Thread Sticky: Old Jeep Voltage Regulators; An Introduction: Section I

    Started by LarrBeard, 08-26-2018 02:19 PM
    2 Attachment(s)
    • Replies: 0
    • Views: 27,731
    LarrBeard
    08-26-2018, 02:19 PM Go to last post

  44. Sticky Thread Sticky: Old Jeep Generators; An Introduction

    Started by LarrBeard, 08-24-2018 09:22 AM
    1 Attachment(s)
    • Replies: 0
    • Views: 18,424
    LarrBeard
    08-24-2018, 09:22 AM Go to last post

  1. Red face Heater Hose

    Started by Durk50, 02-24-2018 12:07 PM
    • Replies: 1
    • Views: 28,298
    gmwillys
    02-26-2018, 05:19 AM Go to last post

  2. Willys Overland "Go-Devil" 4-134 L Engine YouTube Video

    Started by AmyB, 02-22-2018 04:09 PM
    willys jeep video
    • Replies: 0
    • Views: 12,972
    AmyB
    02-22-2018, 04:09 PM Go to last post

  3. CJ-5 Hard Top Pics

    Started by AmyB, 08-12-2014 01:23 PM
    hard top, willys jeep 5 Attachment(s)
    • Replies: 2
    • Views: 31,498
    Durk50
    02-10-2018, 04:31 PM Go to last post

  4. T14 transmission rebuild help

    Started by Sugarloaf, 12-05-2017 11:19 AM
    manual, rebuild, t14, trans
    • Replies: 4
    • Views: 34,307
    gmwillys
    12-07-2017, 06:10 AM Go to last post

  5. Speedometer issue

    Started by Brewster, 11-04-2016 02:16 PM
    5 Attachment(s)
    • Replies: 1
    • Views: 40,369
    LarrBeard
    11-05-2016, 02:43 PM Go to last post

  6. Willys Jeep Paint Color Guide

    Started by AmyB, 07-09-2013 01:17 PM
    guide, paint colors, willys jeep 2 Attachment(s)
    • Replies: 5
    • Views: 24,356
    pelago
    06-15-2016, 08:13 PM Go to last post

  7. 47 loss of power

    Started by bondo bandit, 12-02-2014 09:08 PM
    • Replies: 0
    • Views: 7,261
    bondo bandit
    12-02-2014, 09:08 PM Go to last post

  8. 56 Truck

    Started by tosaint, 04-27-2014 03:22 PM
    • Replies: 0
    • Views: 9,995
    tosaint
    04-27-2014, 03:22 PM Go to last post

  9. 12 Volt Hi-Torque Starter Motor Wiring and Installation Instructions

    Started by AmyB, 11-07-2013 10:27 AM
    • Replies: 0
    • Views: 7,213
    AmyB
    11-07-2013, 10:27 AM Go to last post

  10. Kaiser Frazer KF-3 Tapered Bearing puller made by Willy's Manufuctring

    Started by dustyoldeman, 09-14-2013 06:15 AM
    • Replies: 1
    • Views: 7,244
    dustyoldeman
    09-14-2013, 06:18 AM Go to last post

  11. Clutch Kits for Mahindra Jeeps

    Started by AmyB, 07-31-2013 10:06 AM
    clutch, clutch kits, mahindra, technical help, willys jeep
    • Replies: 0
    • Views: 7,517
    AmyB
    07-31-2013, 10:06 AM Go to last post

  12. Carter YF Carburetor Repair

    Started by AmyB, 07-11-2013 11:47 AM
    carburetor repair, tech tips, willys jeep
    • Replies: 0
    • Views: 7,681
    AmyB
    07-11-2013, 11:47 AM Go to last post

  13. Willys CJ-2A Wiring Diagram Decoded

    Started by RachelH, 07-05-2013 03:24 PM
    cj-2a, cj2a, diagram, electric, jeep, willys, wiring
    • Replies: 0
    • Views: 11,354
    RachelH
    07-05-2013, 03:24 PM Go to last post
Page 2 of 2 FirstFirst 12

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

Forum Rules